2003 escort

2003 FORD ESCORT
97,000 MILES • 6 CYL • FWD • MANUAL
Avatar
ALIBEAR626
  • MEMBER
  • 1 POST
Just reciently purchased a 2003 manual zx2. When practicing getting going and shifing the enginge would overheat badly enough for the coolant to boil in both the coolant reservoir and the radiator as well and will gush coolant from the bottom (we are assuming), but only would gush after overheating other wise it may only drip from time to time. Could it just be the shifting improperly and over working the engine? And what would cause it to loose coolant only after it has overheated to much?

Thanks
Jul 8, 2011 at 1:33 PM
Advertisement
Avatar
ASEMASTER6371
  • CERTIFIED EXPERT
  • 52,796 POSTS
the rad cap sounds like it is doing its job by releasing pressure into the overflow bottle. then the bottle overflows and thus on the ground.
my issue is the overheating. I am afraid you have damaged the head and/or gasket from the overheating. you need a shop to do a special test that is called a leak down test. it will confirm the integrity of the head gasket. I think you will be looking at the gasket being damaged. it is very expensive repair, that is about 1200 or so depending on the damage.
after this is repaired, you still need to find the reason for the overheat. remember, this is a result of the overheat, not the cause. it may be the thermostat, water pump or a clogged radiator.
in the meantime, i suggest you not drive the car until you repair it.

Roy
Jul 8, 2011 at 1:40 PM