Somkes under accelaration 6.5 Diesel

1996 GMC SIERRA
118,000 MILES
Avatar
ROB.KELA
  • MEMBER
  • 21 POSTS
This truck has a lot of black smoke comming from the exhaust when you rev it up or just going down the road. If you could give me some pointers on where to start diagnosing this that would be great.
May 13, 2012 at 2:50 PM
Advertisement
Avatar
ASEMASTER6371
  • CERTIFIED EXPERT
  • 52,796 POSTS
most common issue is the injectors?? how old are they and when did you have them serviced last??

If the injector timing is off, that will cause smoke as well.

Also, fuel quality is another factor. old, bad low cetane fuel will do the same thing.

Roy
May 13, 2012 at 2:53 PM
Avatar
ROB.KELA
  • MEMBER
  • 21 POSTS
changed a fuel solinoid driver also instaled a 8 or a 9 chip the stock was at a 7 does that effect it.
May 13, 2012 at 4:22 PM
Advertisement
Avatar
ASEMASTER6371
  • CERTIFIED EXPERT
  • 52,796 POSTS
the driver, no, the chip should not effect it. is this a turbo?? if it is, there is another reason it may smoke as the seals may be bad and oil may be going out the turbo into the exhaust.

Roy
May 13, 2012 at 4:28 PM
Avatar
ROB.KELA
  • MEMBER
  • 21 POSTS
yes it has a turbo, is it posible the fuel lift pump is bad is there a easy way to check it, the injectors are original. the injector pump was changed at 80,000 after the fsd was changed it stiil never semed right. it is not consuming any oil it seames its getting to much fuel. thanks
Jun 12, 2012 at 12:15 AM
Avatar
ASEMASTER6371
  • CERTIFIED EXPERT
  • 52,796 POSTS
lift pump just supplies fuel to the injector pump. it sounds like you have injector issues.

Roy
Jun 12, 2012 at 12:24 AM
Avatar
ROB.KELA
  • MEMBER
  • 21 POSTS
ok I just wanted to make shure I will order 450.00 In injectors for this thanks.
Jun 12, 2012 at 12:35 AM