if you have fire and gas can the ecu still be bad?

1993 FORD E-SERIES VAN
245,000 MILES
Avatar
DLEE7022
  • MEMBER
  • 13 POSTS
This van has a 4.9l 6 cylinder in it, it will turn over until it kills the battery. I pulled all the plugs checked gap, spark, and they had the right gap had spark and there was a lot of fuel on the plugs. I sprayed them down with starting fluid to clean them up. Doesn't start. Just a few days before this all happened I had installed another alternator bc the other one was going bad. Not sure if maybe that might have been the wrong alternator with too many output amps and possibly sent a serge to the ecu. Any ideas would be greatly appreciated, I'm about ready to throw a match in the tank.

P.S. I have gotten it to start a couple of times since it started the problem and idles fine but runs crappy when driving. It will run until you turn it off and when you try to crank it again its hard to start if it even will.
Thanks again
Jan 22, 2012 at 11:00 PM
Advertisement
Avatar
FIXITMR
  • CERTIFIED EXPERT
  • 9,990 POSTS
so it has spark? have you tried holding pedal to floor when it wont start?
Jan 22, 2012 at 11:29 PM
Avatar
DLEE7022
  • MEMBER
  • 13 POSTS
Yeah it has spark, have held the pedal to the floor doesn't make a difference. It even took the air box loose and sprayed that starting fluid in the throttle body still acted no differently.
Jan 22, 2012 at 11:38 PM
Advertisement
Avatar
FIXITMR
  • CERTIFIED EXPERT
  • 9,990 POSTS
try compression test or stop fuel supply and let it dry out then ad some spray start while cranking?
Jan 23, 2012 at 4:51 AM
Avatar
DLEE7022
  • MEMBER
  • 13 POSTS
Checked compression all cylinders around 125psi. Pulled fuse to the fuel pump cranked it over for about min and a half sprayed more starting fluid in the throttle body, no change.
Jan 23, 2012 at 7:26 PM
Avatar
DLEE7022
  • MEMBER
  • 13 POSTS
Ok just got back from the pos I finally got it to start had to hold pedal to the floor and its running but still running very crappy
Jan 23, 2012 at 8:34 PM
Avatar
FIXITMR
  • CERTIFIED EXPERT
  • 9,990 POSTS
more amps from alt wont hurt but more volts could. should not be higher than 15v preferrably 14v.
Jan 24, 2012 at 12:42 AM
Avatar
DLEE7022
  • MEMBER
  • 13 POSTS
So where do I check my voltage from with my voltage meter
Jan 24, 2012 at 12:57 AM
Avatar
FIXITMR
  • CERTIFIED EXPERT
  • 9,990 POSTS
at battery while running.
Jan 24, 2012 at 4:34 AM
Avatar
DLEE7022
  • MEMBER
  • 13 POSTS
I can't do that when I shut it off yesterday it wouldn't crank back up. would not getting enough amps out of the alternator cause it to do what its doing?
Jan 24, 2012 at 2:43 PM
Avatar
FIXITMR
  • CERTIFIED EXPERT
  • 9,990 POSTS
battery has to be 12v to run system. usually reads at least 12.5 when not running.
Jan 24, 2012 at 4:09 PM
Avatar
DLEE7022
  • MEMBER
  • 13 POSTS
The battery has 12.4VDC across it
Jan 24, 2012 at 4:13 PM
Avatar
FIXITMR
  • CERTIFIED EXPERT
  • 9,990 POSTS
i had a 91 tempo (ford) with 300k that was doin the same thing your van is. way too rich to start, flood right out. i put a momentary switch on the fuel pump and used it to stop pump while cranking till it started then let pump run. never did take time to figure it out. it probably had low compression like your van. dont know if that was part of problem.
Jan 24, 2012 at 4:15 PM
Avatar
DLEE7022
  • MEMBER
  • 13 POSTS
So you think I should just do that?
Jan 24, 2012 at 4:23 PM
Avatar
FIXITMR
  • CERTIFIED EXPERT
  • 9,990 POSTS
voltage sounds right. butyou wont know till started. my tempo ran fine after starting. yours does not. i rigged it as temp fix so i could drive and ended up leaving that way.
Jan 24, 2012 at 5:18 PM
Avatar
DLEE7022
  • MEMBER
  • 13 POSTS
Do you think that it could just always be getting too much fuel and cause it to flood out even when running? It idles fine and if you drive it it'll drive as long as you don't push the pedal more than half way
Jan 24, 2012 at 5:39 PM
Avatar
FIXITMR
  • CERTIFIED EXPERT
  • 9,990 POSTS
if it was running to rich it would turn plugs sooty black. you have spark is it strong and blue? will it jump a bigger gap then plug gap?
Jan 25, 2012 at 5:22 AM
Avatar
DLEE7022
  • MEMBER
  • 13 POSTS
spark is orange in most of them a little blue in a couple of them
Jan 25, 2012 at 3:56 PM
Avatar
FIXITMR
  • CERTIFIED EXPERT
  • 9,990 POSTS
check coil for 12v while cranking.
Jan 26, 2012 at 12:04 PM
Avatar
DLEE7022
  • MEMBER
  • 13 POSTS
Ok will check that later today.
Jan 26, 2012 at 12:26 PM
Avatar
RIVERMIKERAT
  • CERTIFIED EXPERT
  • 6,110 POSTS
dlee, how was that voltage at the coil?
Have you checked fuel pressure yet?
Jan 27, 2012 at 10:58 PM
Avatar
DLEE7022
  • MEMBER
  • 13 POSTS
Havent gotten a chance to check either one yet hoping to check it tomorrow
Jan 27, 2012 at 11:58 PM
Avatar
RIVERMIKERAT
  • CERTIFIED EXPERT
  • 6,110 POSTS
Ok. Let us know what you find out.
Jan 28, 2012 at 12:20 AM
Avatar
DLEE7022
  • MEMBER
  • 13 POSTS
Will do thanks
Jan 28, 2012 at 12:55 AM
Avatar
RIVERMIKERAT
  • CERTIFIED EXPERT
  • 6,110 POSTS
No problem.
Jan 28, 2012 at 3:21 AM